RESUMO
The search of sustainable and environmentally friendly alternatives to obtain compounds for different industrial sectors has grown exponentially. Following the principles of biorefinery and circular bioeconomy, processes in which the use of natural resources such as macroalgae biomass is prioritized are required. This review focuses on a description of the relevance, application and engineering platforms of hydrothermal systems and the operational conditions depending on the target as an innovative technology and bio-based solution for macroalgae fractionation in order to recover profitable products for industries and investors. In this sense, hydrothermal treatments represent a promising alternative for obtaining different high value-added compounds from this biomass; since, the different variations in terms of operating conditions, gives great versatility to this technology compared to other types of processing, allowing it to be adapted depending on the objective, whether it is working under sub/super critical conditions, thus expanding its field of application.
Assuntos
Alga Marinha , Biocombustíveis , Biomassa , Fracionamento Químico , Engenharia , TecnologiaRESUMO
Aristotelia chilensis is a plant rich in phenolics and other bioactive compounds. Their leaves are discarded as waste in the maqui berry industry. A new application of these wastes is intended by the recovery of bioactive compounds using pressurized hot water extraction with conventional or microwave heating. Both technologies have been selected for their green character regarding the type of solvent and the high efficiency in shorter operation times. Extractions were performed in the temperature range 140-200 °C with a solid/liquid ratio of 1:15 (w:w). The extracts' total phenolic content, antioxidant capacity, and saccharides content obtained with both heating methods were measured. Additionally, the thermo-rheological properties of the gelling matrix enriched with these extracts were analyzed. Optimum conditions for lyophilized extracts were found with conventional heating, at 140 °C and 20 min extraction; 250.0 mg GAE/g dry extract and 1321.5 mg Trolox/g dry extract. Close to optimum performance was achieved with microwave heating in a fraction of the time (5 min) at 160 °C (extraction), yielding extracts with 231.9 mg GAE/g dry extract of total phenolics and antiradical capacity equivalent to 1176.3 mg Trolox/g dry extract. Slightly higher antioxidant values were identified for spray-dried extracts (between 5% for phenolic content and 2.5% for antioxidant capacity). The extracts obtained with both heating methods at 200 °C contained more than 20% oligosaccharides, primarily glucose. All the formulated gelling matrices enriched with the obtained extracts displayed intermediate gel strength properties. The tested technologies efficiently recovered highly active antioxidant extracts, rich in polyphenolics, and valuable for formulating gelling matrices with potential applicability in foods and other products.
Assuntos
Elaeocarpaceae/química , Glucose/isolamento & purificação , Hidrogéis/química , Oligossacarídeos/isolamento & purificação , Glucose/química , Oligossacarídeos/química , Pressão , Temperatura , Água/químicaRESUMO
The integral valorization of artichoke bracts generated during industrial canning of artichoke was assessed. The extraction of bioactive compounds was addressed with pressurized hot water under subcritical conditions. The performance of this stage on the extraction of phenolics with antioxidant properties and the saccharidic fraction using conventional and microwave heating was compared. The microwave assisted process was more efficient than the conventional one regarding extraction yields of total solubles, and glucose and fructose oligomers and phenolics, because lower operational temperatures and shorter times were needed. Degradation of fructose oligomers was observed at temperatures higher than 160 °C, whereas the maximal phenolic content occurred at 220 °C. Both the extracts and the residual solids, obtained at conditions leading to maximum phenolics yields, were evaluated for the production of starch-based hydrogels, supplemented with Paulownia leaves' aqueous extracts.
Assuntos
Cynara scolymus/química , Química Verde , Temperatura Alta , Hidrogéis , Lamiales/química , Extratos Vegetais/química , Hidrogéis/síntese química , Hidrogéis/químicaRESUMO
Multi-response optimization of hot pressurized liquid extraction (HPLE) was applied for the first time to obtain maqui (Aristotelia chilensis [Mol.] Stuntz) leaf extracts. The total polyphenol content (TPC), the antioxidant capacity (AC) as well as the total polyphenol purity of the maqui leaf extracts were accurately predicted (RSD < 8%) at the evaluated extraction scales. The optimum HPLE conditions that prioritized TPC and AC equally (OPT1) recovered ~3 times more TPC (205.14 mg GAE/g leaves) than maqui leaf extracts obtained by maceration, while the extract that prioritized purity over TPC and AC presented the highest purity (36.29%) and an EC50 ~3 times lower than currently reported values. It was found by multi-response optimization that maqui leaves and HPLE are among the best natural sources and extraction techniques, respectively, to recover protocatechuic acid, quercetin, and catechin.