RESUMO

The effect of the use of Nilo tilapia filleting residues in the production of pâtés with the addition of oregano essential oil stored for 90 days at 4 °C was evaluated. For that, 5 treatments were performed as follows: TSA-control treatment; TES with the addition of sodium erythorbate; and formulation TOE1 with 600 ppm oregano essential oil; TOE2 with 1000 ppm essential oil; and TOE3 with 1400 ppm essential oil. The pâtés showed adequate technological and physicochemical characteristics and microbiological counts within the legislation standards. No significant differences were observed in the luminosity of the pâté formulations during storage, and the addition of oil contributed to the increase in a* values and stability of b* values. Regarding the lipid and protein oxidation, TOE3 showed lower values at the end of the shelf-life. The addition of essential oil did not affect the hardness and cohesiveness of the products. The fatty acids in greater amounts in the samples were linoleic, oleic, palmitic, and stearic acids. The analysis of biogenic amines indicated that only the treatments with the highest amounts of sodium erythorbate (TES and TOE1) showed losses of spermidine. It was observed that decreasing the inclusion of sodium erythorbate and increasing the inclusion of oregano essential oil resulted in a drop in cadaverine values. A total of 46 volatile compounds were detected in the samples with the highest amount of free fatty acids and all the formulations were well accepted sensorially.

Assuntos

RESUMO

The objective of this work was to characterize the internal temperature of the carcass, pH and sarcomere length in four categories of body weight at a slaughter. The categories were: category 1, animals up to 1.5 kg, category 2, animals from 1.501 to 2.5 kg, category 3, animals from 2.501 to 3.5 kg and category 4, animals over 3.501 kg. The time intervals evaluated were 0.5, 2, 4, 6, 8, 10, 12, 14, 16, 18, 24 and 36 hours after bleeding, therefore, a factorial scheme (4 x 12) was used, in which where four categories of pre-slaughter weight and the behavior of the carcasses during the post-slaughter time were evaluated. There was no interaction effect between the weight categories and the time for the variation of the carcass internal temperature, pH and sarcomere length, but when only the time of rigor was evaluated, there were significant differences for the analyzed parameters. The internal temperature of the initial average carcass (0.5 hours) was 16.02°C, reaching 3.80°C at 36 hours post-slaughter. In addition, the lowest average pH found was at 24 hours, with a value of 5.39. Regarding the sarcomere length, the smallest mean length observed was 1.41 µm at 16 hours post-slaughter and the final mean length (36 hours) was 1.89 µm. It was concluded that the analyzed margin of the categories of body weight at slaughter did not interfere in the variation of temperature, pH and sarcomere length during the post-mortem of the Pantanal caiman.(AU)

O objetivo do trabalho foi caracterizar a temperatura interna da carcaça, o pH e o comprimento de sarcômero em quatro categorias de peso corporal ao abate. As categorias foram: categoria 1, animais com até 1,5 kg, categoria 2, animais de 1,501 a 2,5 kg, categoria 3, animais de 2,501 a 3,5 kg e categoria 4, animais acima de 3,501 kg. Os intervalos de tempo avaliados foram 0,5, 2, 4, 6, 8, 10, 12, 14, 16, 18, 24 e 36 horas, após a sangria, portanto, foi utilizado um esquema fatorial (4 x 12) que avaliou quatro categorias de peso e o comportamento das carcaças ao decorrer do tempo. Não houve efeito de interação entre as categorias de peso e o tempo para a variação da temperatura interna da carcaça, pH e comprimento de sarcômero, mas quando avaliado apenas o tempo de rigor, houve diferenças significativas para os parâmetros analisados. A temperatura interna da carcaça média inicial (0,5 horas) foi de 16,02°C, chegando a 3,80°C nas 36 horas pós-abate. Além disso, o menor pH médio encontrado foi as 24 horas, com valor de 5,39. Em relação ao comprimento de sarcômero o menor comprimento médio observado foi de 1,41 µm nas 16 horas pós-abate e o comprimento médio final (36 horas) foi de 1,89 µm. Conclui-se que a margem analisada das categorias de peso corporal ao abate, não interferiram na variação de temperatura, pH e comprimento de sarcômero durante o post mortem do jacaré-do-Pantanal.(AU)

Assuntos

RESUMO

This study aimed to compare the resistance of the Oryctolagus cuniculus L. (rabbit) and Oreochromis niloticus L. (Nile tilapia) skins, as well as to observe the design of the flower of these skins and the morphology of the dermis. Tilapia and rabbit skins were placed inside the same equipment (tannery machine) for the chromium salt tanning process. The flower design of the fish leather distinguishes it from the rabbit leather, the latter being constituted by the opening of the hair follicles and pores, while the fish leather is constituted by the presence of protective lamellae and insertion of the scales. The dermis of rabbit skin consists of thick bundles of collagen fibers arranged in all directions, which differs from the morphology observed in the dermis of fish skin. However, in the Nile tilapia skin dermis, overlapping and parallel layers of longitudinal collagen fiber bundles are observed, these layers are interspersed with fiber bundles crossing the sking surface (transversely), tying the fibers together and providing greater strength, which can be proven by the strength test. The fish leathers, despite having less thickness (1.0 mm), demonstrated significantly greater tensile strength (13.52 ± 1.86 N mm-2) and tear strength (53.85 ± 6.66 N mm-2) than rabbit leathers, that is, (8.98 ± 2.67 N mm-2) and (24.25 ± 4.34 N mm-2). However, rabbit leather demonstrated higher elasticity (109.97 ± 13.52%) compared to Nile tilapia leather (78.97 ± 8.40%). It can be concluded that although the rabbit leather is thicker due to the histological architecture of the dermis (thick bundles of collagen fibers arranged in all directions with no pattern of organization of collagen fibers), it shows less resistance than Nile tilapia leather, which demonstrates an organization of overlapping and parallel layers and intercalating collagen fiber bundles transversally to the surface, functioning as tendons for the swimming process. It is recommended to use a piece of fabric (lining) together with the fleshy side of the rabbit leather, to increase resistance when used in clothing and footwear, as these products require greater tensile strength. Thus, it minimizes this restriction for the use of rabbit leather in the aforementioned purposes.

Assuntos

RESUMO

In tilapia aquaculture, the cultivation of single-sex animals is extremely widespread, as it allows for the standardization of lots, in addition to improving the general performance of the animals. However, it is possible that hormonal inversion interacts with other factors, such as environmental and nutritional management, and modulates the immune response and antioxidant system of animals in a distinct manner. In order to test this hypothesis, an experiment was carried out using Nile tilapia larvae six days after hatching, divided into four experimental groups: NI (non-inverted animals), I (sexual inverted animals), NI + M (non-inverted supplemented with microencapsulated products) and I + M (sexual inverted and supplemented with microencapsulated products; half of which were subjected to transportation-related stress after 28 days of the experiment. At the end, the survival rate was evaluated; the gene expression of heat shock protein (HSP70), interleukin 1 beta (IL-1ß) and cyclooxygenase-2 (COX 2) via RT-PCR; also evaluated were the activity of catalase (CAT) and superoxide dismutase (SOD) enzymes, as well as the total antioxidant capacity by 2,2-diphenyl-1-picryl-hydrazyl (DPPH). Animals from the I and I + M groups had the highest survival rate (p < 0.001) regardless of transportation stress. The highest expressions of HSP70 were found in the NI group (p < 0.001, with and without transportation). For the IL-1ß gene, there was an increase in expression for animals belonging to groups NI and NI + M (no transportation); and NI (p < 0.0001, with transportation). Increased COX 2 expression was observed for all groups after transportation (p < 0.0001). The highest SOD activities were observed in groups I and I + M (without transportation, p = 0.0004), and I (with transportation, p < 0.0001). The transportation decreased the total antioxidant capacity of DPPH in all treatments (p < 0.001). Finally, when evaluating all of the results together, we came to a conclusion that sex inversion improves the immune response and antioxidant profile of animals under stressful conditions when associated with microencapsulated dietary supplementation.

Assuntos

RESUMO

BACKGROUND: The present study aimed to evaluate the effects of hot smoking and liquid smoke on process yield, physicochemical properties, microbiological parameters, fatty acid profile, benzo(a)pyrene levels, and sensory profile of Pantanal yacare tail fillets. The fillets were subjected to two types of smoking processes: hot smoking and liquid smoke flavoring. RESULTS: The process yield of liquid-smoked fillets was higher (69.8%) compared to hot-smoked fillets (58.0%). All fillets were with good microbiological quality and low benzo(a)pyrene levels and were well accepted by consumers. The hot-smoked fillets and the liquid-smoked fillets presented 456.2 and 589.7 g kg-1 moisture, 262.3 and 263.7 g kg-1 crude protein, 218 and 85 g kg-1 total lipids, and 26.0 and 20.9 g kg-1 ash, respectively. The major fatty acids identified in the smoked tail fillets were palmitic, stearic, oleic, and linoleic acids. CONCLUSION: The liquid-smoked fillets had lower lipid content, and higher process yield because of lower losses; thus, they proved to be more advantageous and practical to obtain than the hot-smoked fillets. © 2022 Society of Chemical Industry.

Assuntos