RESUMO
A full scale UASB reactor treating the effluent of a malting plant was operated during nearly two years. During 37 weeks of operation the reactor worked with a COD removal efficiency of 80% and a biogas production of nearly 300 m(3)/d with a methane content of 77%. After the start up and during these months of operation the volumetric organic load was 4 kgCOD/m(3).d and the specific organic load was between 0.2-0.4 kgCOD/kgVSS.d. The sludge SMA in this period was around 0.25 kgCOD/kg VSS.d. On week 37 as a result of a problem at the industrial process the pH in the reactor dropped to a value of 4.8. After pH recovering, the reactor worked with fluctuating COD values in the exit and showed a downward trend in the COD removal efficiency. On week 81 the presence of filaments in the granules was detected. High proportion of Chloroflexi filaments were detected by FISH in the sludge. Changes in the microbial population caused by the low pH probably destabilize the reactor performance. The presence of filamentous granules in the sludge and its further growing could be encouraged by the pH drop and the low specific organic load applied to the reactor. The low specific organic load was a consequence of the high VSS content in the UASB reactor, due to the lack of purges. The length of the filaments attached to the granules grew throughout time. In order to eliminate the sludge with poor settlement properties a recycle was applied to the reactor. As a consequence, low amount of granular sludge stayed in the reactor. At the end, COD concentration in the influent reached higher values than in normal operation; at the same time a complete sludge wash out occurred. On the other hand, using the same sludge (after the recycle implementation) in a bench scale reactor the good properties of the sludge were completely recovered.
Assuntos
Reatores Biológicos/microbiologia , Esgotos , Eliminação de Resíduos Líquidos/métodos , Chloroflexi/crescimento & desenvolvimento , Concentração de Íons de Hidrogênio , Metano/metabolismoRESUMO
At the present time, organic solid wastes from industries and agricultural activities are considered to be promising substrates for biogas production via anaerobic digestion. Moreover solids stabilisation is required before reutilization or disposal. Slaughterhouses are among the most important industries in Uruguay and produce 150,000 tons of ruminal content (RC) and 30,000 tons of blood per year. In order to determine the influence of the solids and blood contents, the ammonia inhibition and the inoculum adaptation co-digestion batch tests were performed. A set of experiences with TS concentration of 2.5%, 5% and 7.5% and different ratios of RC/blood were carried out using an inoculum from an UASB reactor. In all experiences fast blood hydrolisation was observed. A higher methane production was detected in the experiences with higher TS content. However, the fraction of solids degradation was lower in these experiences. A plateau in the biogas production was found. The free ammonia level, which was above the reported inhibitory levels, could explain this behaviour. After the inhibition period the biogas production restarted probably due to the biomass acclimatisation to the ammonia. In order to determine the inoculum adaptation a new experiment was performed. The inoculum used was the sludge coming from the first set of experiences. Based upon batch tests a 3.5 m3 pilot reactor was designed and started up. Ammonia inhibition was avoided by the start-up strategy and in two weeks the biogas production was 3.5 m3/d. The VS stabilisation with a solid retention time of 20 days was of 43%. The pilot reactor working at steady state had a TS concentration of 3-4% with a ratio of RC/blood of 10:1 at the entrance.
Assuntos
Matadouros , Sangue , Compostos de Amônio Quaternário/síntese química , Eliminação de Resíduos/métodos , Rúmen/química , Animais , UruguaiRESUMO
We report electron paramagnetic resonance (EPR) experiments in frozen solutions of unreduced and reduced photosynthetic reaction centers (RCs) from Rhodobacter sphaeroides R-26 in which Fe2+ has been chemically replaced by the isotope 65Cu2+. Samples in which the primary quinone acceptor QA is unreduced (Cu2+QA:RCs) give a powder EPR spectrum typical for Cu2+ having axial symmetry, corresponding to a d(x2 - y2) ground state orbital, with g values g parallel = 2.314 +/- 0.001 and g perpendicular = 2.060 +/- 0.003. The spectrum shows a hyperfine structure for the nuclear spin of copper (65I = 3/2) with A parallel = (-167 +/- 1) x 10(-4) cm-1 and /A perpendicular/ = (16 +/- 2) x 10(-4) cm-1, and hyperfine couplings with three nitrogen ligands. This has been verified in samples containing the naturally occurring 14N isotope (l = 1), and in samples where the nitrogen ligands to copper were replaced by the isotope 15N (l = 1/2). We introduce a model for the electronic structure at the position of the metal ion which reflects the recently determined three-dimensional structure of the RCs of Rb. sphaeroides (Allen, J. P., G. Feher, T. O. Yeates, H. Komiya, and D. C. Rees. 1987. Proc. Natl. Acad. Sci. USA. 84:5730: Allen, J. P., G. Feher, T. O. Yeates, H. Komiya, and D. C. Rees. 1988. Proc. Natl. Acad. Sci. USA, 85:8487) as well as our EPR results. In this model the copper ion is octahedrally coordinated to three nitrogens from histidine residues and to one carboxylate oxygen from a glutamic acid, forming a distorted square in the plane of the d(x2 = y2) ground state orbital. It is also bound to a nitrogen of another histidine and to the other carboxylate oxygen of the same glutamic acid residue, in a direction approximately normal to this plane. The EPR spectrum changes drastically when the quinone acceptor QA is chemically reduced (Cu2+QA-:RCs); the change is due to the exchange and dipole-dipole interactions between the Cu2+ and QA- spins. A model spin Hamiltonian proposed for this exchange coupled cooper-quinone spin dimer accounts well for the observed spectra. From a comparison of the EPR spectra of the Cu2+QA:RC and CU2+QA-:RC complexes we obtain the values /J0/ = (0.30 +/- 0.02) K for the isotropic exchange coupling, and /d/ = (0.010 +/- 0.002) K for the projection of the dipole-dipole interaction tensor on the symmetry axis of the copper spin. From the EPR experiments only the relative signs of J0 and d can be deduced; it was determined that they have the same sign. The magnitude of the exchange coupling calculated for Cu2+QA-:RC is similar to that observed for the Fe2+QA-:RC complex (J0 = -0.43K). The exchange coupling is discussed in terms of the superexchange paths connecting the Cu2+ ion and the quinone radical using the structural data for the RCs of Rb. sphaeroides. From the value of the dipole-dipole interaction, d, we determined R approximately 8.4 A for the weighted distance between the metal ion and the quinone in reduced RCs, which is to be compared with 10 A obtained from x-ray analysis of unreduced RCs. This points to a shortening of the Cu2+ -QA- distance upon reduction of the quinone, as has been proposed by Allen et al. (1988).