RESUMO

In this study, the second-life application of Saccharomyces cerevisiae obtained from brewery wastewater was evaluated in the biosorption of Se(IV) (Na2SeO3) sorbate in residue generated from a fine chemical industry. Biosorption experiments were carried out with different Se(IV) concentrations (A = 7.5 to 30.0 mg L-1 dissolved in deionized water or industrial effluent) and different biosorbent concentrations (B = 2.0 to 52.5 g L-1, dry mass). Inactive microbial biomass was evaluated in a wet and dehydrated state. The highest selenium removal efficiency (biosorption efficiency-R = 97.5%) was achieved with the same concentrations of sorbate in deionized water, using 24.0 g L-1 of wet cells. In contrast, the industrial effluent treatment showed lower biosorption efficiency (R = 83.3%) due to a large amount of other salts in the medium, mainly sulphur. Overall, the use of smaller amounts of biosorbent had a biosorption capacity of approximately five times greater than when 24.0 g L-1 in industrial effluent treatment was used. However, as reducing the concentration of the contaminant contained in the wastewater is the primary goal of this study, a more significant amount of biosorbent is recommended.

Assuntos

RESUMO

Bisphenol A is an endocrine interfering compound, produced and used on a large scale worldwide. Chemical and biologic methods can be used to remove it from the environment. Biological methods are considered less costly, safer and, according to green chemistry definitions, an environmentally correct method. Considering the use of a crude enzyme broth, without any downstream process, the costs could be mostly reduced. Thus, the removal of bisphenol A by Pleurotus sajor-caju crude enzyme broth was investigated. Initially, the agro-industrial wastes were characterized and, the composition of the culture medium and the bioreactor culture conditions were defined. The enzyme produced in the highest concentration was characterized and the crude broth used in the bisphenol A removal assays. The OXI45 culture medium presented the highest laccase activity (1,850.7 U L-1, 350 rpm). Greater laccase stability was observed at 20 - 40 oC and pHs 5 - 7. Vanillin and ferulic acid (considered mediator compounds) were identified in the crude broth, probably helping on the obtention of the high value of removal effectiveness (0.052 mg U-1 h-1). The results indicate the potential use of the Pleurotus sajor-caju crude enzyme broth to obtain an enzymatic formulation for application in the environmental area.

Assuntos

RESUMO

Bisphenol-A is currently considered an environmental pollutant, capable of interfering in the endocrine system of organisms and causing alterations in its development and reproductive system. An alternative method to the chemical treatment of this pollutant has been the use of oxidative enzymes, especially laccases produced by fungi. In order to reduce production costs, agro-industrial waste can be used in the culture medium composition. Nonionic surfactants, which are only slightly toxic to biological membranes, can be applied, as well as Tween 80, to facilitate the excretion of these enzymes into the culture medium. The objectives of this work were: a) characterize the immersion water of banana straw used in the formulation of the culture medium; b) evaluate laccase production by Pleurotus sajor-caju in culture medium with and without addition of Tween 80, through shaken flasks; c) evaluate the efficiency of the crude enzyme broth in degrading bisphenol-A. The shaken flasks were incubated at 30°C for 12 days. The immersion water had a C:N ratio of 13.8, ash percentage of 28.6%, and pH close to neutrality. The addition of Tween 80 on the culture medium (7.5%, m/v) yielded laccase activity and productivity values equal to 3,016.47 U L-1 and 502.7 U L-1 day-1, respectively. These values were 50 and 33.5 times higher than those obtained in the culture medium without addition of Tween 80 for laccase activity and productivity, respectively. The crude enzyme broth degraded 100% of bisphenol-A after 48 hours, regardless of concentration (500, 750 and 1,000 mg L-1).(AU)

O bisfenol-A é considerado um poluente ambiental capaz de interferir no sistema endócrino dos organismos, ocasionando alterações em seu desenvolvimento e sistema de reprodução. Um método alternativo ao tratamento químico desse tipo de poluente tem sido a utilização de enzimas oxidativas, especialmente as lacases, produzidas por fungos. A fim de diminuir custos de produção, resíduos agroindustriais podem compor o meio de cultivo. Assim, surfactantes não iônicos e pouco tóxicos para as membranas biológicas, como o Tween 80, podem ser utilizados para facilitar a excreção dessas enzimas para o meio de cultivo. Os objetivos deste trabalho foram: caracterizar quimicamente o resíduo água de imersão de palha de bananeira, usado na formulação do meio de cultivo; avaliar a produção de lacase por Pleurotus sajor-caju em meio de cultivo líquido (frascos Erlenmeyer) com e sem adição de Tween 80; e avaliar a eficiência do caldo enzimático bruto em degradar bisfenol-A. Os frascos foram incubados a 30°C, por 12 dias. A água de imersão apresentou relação C:N 13,8, percentual de cinzas 28,6% e pH próximo da neutralidade. O cultivo adicionado de Tween 80 (7,5%, m/v) propiciou valores de atividade e produtividade em lacase iguais a 3.016,47 U L-1 e 502,7 U L-1 dia-1, respectivamente. Esses valores são 50 e 33,5 vezes maiores que os obtidos no cultivo sem adição de Tween 80, para atividade e produtividade em lacase, respectivamente. O caldo enzimático bruto degradou 100% do bisfenol-A após 48 horas, independentemente da concentração (500, 750 e 1.000 mg L-1).(AU)

Assuntos

RESUMO

Bisphenol-A is currently considered an environmental pollutant, capable of interfering in the endocrine system of organisms and causing alterations in its development and reproductive system. An alternative method to the chemical treatment of this pollutant has been the use of oxidative enzymes, especially laccases produced by fungi. In order to reduce production costs, agro-industrial waste can be used in the culture medium composition. Nonionic surfactants, which are only slightly toxic to biological membranes, can be applied, as well as Tween 80, to facilitate the excretion of these enzymes into the culture medium. The objectives of this work were: a) characterize the immersion water of banana straw used in the formulation of the culture medium; b) evaluate laccase production by Pleurotus sajor-caju in culture medium with and without addition of Tween 80, through shaken flasks; c) evaluate the efficiency of the crude enzyme broth in degrading bisphenol-A. The shaken flasks were incubated at 30°C for 12 days. The immersion water had a C:N ratio of 13.8, ash percentage of 28.6%, and pH close to neutrality. The addition of Tween 80 on the culture medium (7.5%, m/v) yielded laccase activity and productivity values equal to 3,016.47 U L-1 and 502.7 U L-1 day-1, respectively. These values were 50 and 33.5 times higher than those obtained in the culture medium without addition of Tween 80 for laccase activity and productivity, respectively. The crude enzyme broth degraded 100% of bisphenol-A after 48 hours, regardless of concentration (500, 750 and 1,000 mg L-1).(AU)

O bisfenol-A é considerado um poluente ambiental capaz de interferir no sistema endócrino dos organismos, ocasionando alterações em seu desenvolvimento e sistema de reprodução. Um método alternativo ao tratamento químico desse tipo de poluente tem sido a utilização de enzimas oxidativas, especialmente as lacases, produzidas por fungos. A fim de diminuir custos de produção, resíduos agroindustriais podem compor o meio de cultivo. Assim, surfactantes não iônicos e pouco tóxicos para as membranas biológicas, como o Tween 80, podem ser utilizados para facilitar a excreção dessas enzimas para o meio de cultivo. Os objetivos deste trabalho foram: caracterizar quimicamente o resíduo água de imersão de palha de bananeira, usado na formulação do meio de cultivo; avaliar a produção de lacase por Pleurotus sajor-caju em meio de cultivo líquido (frascos Erlenmeyer) com e sem adição de Tween 80; e avaliar a eficiência do caldo enzimático bruto em degradar bisfenol-A. Os frascos foram incubados a 30°C, por 12 dias. A água de imersão apresentou relação C:N 13,8, percentual de cinzas 28,6% e pH próximo da neutralidade. O cultivo adicionado de Tween 80 (7,5%, m/v) propiciou valores de atividade e produtividade em lacase iguais a 3.016,47 U L-1 e 502,7 U L-1 dia-1, respectivamente. Esses valores são 50 e 33,5 vezes maiores que os obtidos no cultivo sem adição de Tween 80, para atividade e produtividade em lacase, respectivamente. O caldo enzimático bruto degradou 100% do bisfenol-A após 48 horas, independentemente da concentração (500, 750 e 1.000 mg L-1).(AU)

Assuntos

RESUMO

Fungi of Pleurotus genus have attracted a great interest due to their medicinal properties such as anti-inflammatory, antimicrobial and antitumor. These properties are attributed mainly to polysaccharides synthesized by Pleurotus. This work aimed to study the mycelial growth of P. ostreatus in submerged culture, evaluating the influence of the initial concentration of substrate (20 and 40 g/L of glucose) and the pH (4 and 6) on kinetic parameters of production of biomass. The effectiveness of different doses (10, 30 and 50 mg/kg) of a mycelium polysaccharide fraction extracted from P. ostreatus in reducing Sarcoma 180 development in mice was also verified. In the range of this study, maximum concentration of mycelial biomass (about 12.8 g/L) was obtained using 40.0 g/L of glucose, at pH 4.0. The total biomass productivity (Px) was not significantly affected by substrate concentration and pH, reaching values of 0.034 g/L.h. Sarcoma 180 tumor weight was reduced in 74.1, 75.5 and 53.7% when 10, 30 and 50 mg/kg were administered, respectively. These results show the high antitumor potential of intracellular polysaccharide fraction of mycelial biomass of P. ostreatus, particularly at lower doses of 10 and 30 mg/kg.

Assuntos

RESUMO

ABSTRACT Fungi of Pleurotus genus have attracted a great interest due to their medicinal properties such as anti-inflammatory, antimicrobial and antitumor. These properties are attributed mainly to polysaccharides synthesized by Pleurotus. This work aimed to study the mycelial growth of P. ostreatus in submerged culture, evaluating the influence of the initial concentration of substrate (20 and 40 g/L of glucose) and the pH (4 and 6) on kinetic parameters of production of biomass. The effectiveness of different doses (10, 30 and 50 mg/kg) of a mycelium polysaccharide fraction extracted from P. ostreatus in reducing Sarcoma 180 development in mice was also verified. In the range of this study, maximum concentration of mycelial biomass (about 12.8 g/L) was obtained using 40.0 g/L of glucose, at pH 4.0. The total biomass productivity (Px) was not significantly affected by substrate concentration and pH, reaching values of 0.034 g/L.h. Sarcoma 180 tumor weight was reduced in 74.1, 75.5 and 53.7% when 10, 30 and 50 mg/kg were administered, respectively. These results show the high antitumor potential of intracellular polysaccharide fraction of mycelial biomass of P. ostreatus, particularly at lower doses of 10 and 30 mg/kg.

Assuntos

RESUMO

This study evaluated the use of immersion water from peach palm leaves (PPLDA) as a component of the culture medium for the maintenance of Pleurotus spp. and the use of agricultural waste, peach palm leaves, as inoculum support for the fungi. The performance of the inoculum based on peach palm leaves (PPL) for the production of Pleurotus spp. fruiting bodies was compared with that using wheat grains (WG) as inoculum support. PPLDA culture medium (immersion water of peach palm leaves, dextrose, and agar) showed a lower radial velocity of mycelial growth for both fungi than that obtained with the culture medium WDA (wheat extract, dextrose and agar), commonly used as maintenance medium for Pleurotus spp. However, the type of inoculum support does not significantly influence the linear velocity of P. ostreatus mycelial growth, reaching 6.71 mm/day on wheat grains and 6.18 mm/day on peach palm leaves. Thus, when the inoculum based on peach palm leaves is utilized, the immersion water used for preparing this support can be used for preparing the PPLDA maintenance culture medium, diminishing the production costs of Pleurotus mushrooms. Data also showed that when Pleurotus sajor-caju was cultivated on peach palm leaves, using PPL as inoculum support, the fruiting bodies production parameters (Y = 47%, BE = 3% and Pr = 0.2 g/day) did not differ from that obtained using WG.(AU)

Este trabalho avaliou a utilização da água de imersão das folhas de pupunheira como componente do meio de cultivo para manutenção da cepa fúngica e a produção de inóculo de Pleurotus spp. utilizando como suporte folhas de pupunheira, um resíduo agrícola. Ainda, para verificar a capacidade do inóculo à base de folhas de pupunheira (FP) de produzir corpos frutíferos, foi realizado um experimento comparando FP com o inóculo à base de grãos de trigo (GT). Para tanto, realizou-se a comparação das velocidades de crescimento radial entre o meio de cultivo TDA (extrato de trigo, dextrose e ágar) utilizado para a manutenção de fungos do gênero Pleurotus e o meio FPDA (água de imersão de folhas de pupunheira, dextrose e ágar), e a comparação das velocidades de crescimento linear entre os grãos de trigo, utilizados como suporte para o inóculo de fungos do gênero Pleurotus e as folhas de pupunheira. O meio de cultivo TDA apresentou velocidade radial superior ao meio FPDA para as duas espécies, no entanto, o tipo de suporte não influenciou significativamente a velocidade de crescimento linear de P. ostreatus , que apresentou 6,71 mm/dia em grãos de trigo e 6,18 mm/dia em folhas de pupunheira. Assim, quando o inóculo à base de folhas de pupunheira é utilizado, a água de imersão deste suporte pode ser aproveitada para a confecção do meio de cultivo de manutenção (FPDA), diminuindo os custos produção. Observou-se que Pleurotus sajor-caju , quando cultivado em folhas de pupunheira utilizando inóculo FP, apresentou cerca de 47% de rendimento, 3% de eficiência biológica e 0,2 g/dia de produtividade, sem diferença significativa com o inóculo GT.(AU)

Assuntos

RESUMO

Este trabalho avaliou a utilização da água de imersão das folhas de pupunheira como componente do meio de cultivo para manutenção da cepa fúngica e a produção de inóculo de Pleurotus spp. utilizando como suporte folhas de pupunheira, um resíduo agrícola. Ainda, para verificar a capacidade do inóculo à base de folhas de pupunheira (FP) de produzir corpos frutíferos, foi realizado um experimento comparando FP com o inóculo à base de grãos de trigo (GT). Para tanto, realizou-se a comparação das velocidades de crescimento radial entre o meio de cultivo TDA (extrato de trigo, dextrose e ágar) utilizado para a manutenção de fungos do gênero Pleurotus e o meio FPDA (água de imersão de folhas de pupunheira, dextrose e ágar), e a comparação das velocidades de crescimento linear entre os grãos de trigo, utilizados como suporte para o inóculo de fungos do gênero Pleurotus e as folhas de pupunheira. O meio de cultivo TDA apresentou velocidade radial superior ao meio FPDA para as duas espécies, no entanto, o tipo de suporte não influenciou significativamente a velocidade de crescimento linear de P. ostreatus, que apresentou 6,71 mm/dia em grãos de trigo e 6,18 mm/dia em folhas de pupunheira. Assim, quando o inóculo à base de folhas de pupunheira é utilizado, a água de imersão deste suporte pode ser aproveitada para a confecção do meio de cultivo de manutenção (FPDA), diminuindo os custos produção. Observou-se que Pleurotus sajor-caju , quando cultivado em folhas de pupunheira utilizando inóculo FP, apresentou cerca de 47% de rendimento, 3% de eficiência biológica e 0,2 g/dia de produtividade, sem diferença significativa com o inóculo GT.(AU)

This study evaluated the use of immersion water from peach palm leaves (PPLDA) as a component of the culture medium for the maintenance of Pleurotus spp. and the use of agricultural waste, peach palm leaves, as inoculum support for the fungi. The performance of the inoculum based on peach palm leaves (PPL) for the production of Pleurotus spp. fruiting bodies was compared with that using wheat grains (WG) as inoculum support. PPLDA culture medium (immersion water of peach palm leaves, dextrose, and agar) showed a lower radial velocity of mycelial growth for both fungi than that obtained with the culture medium WDA (wheat extract, dextrose and agar), commonly used as maintenance medium for Pleurotus spp. However, the type of inoculum support does not significantly influence the linear velocity of P. ostreatus mycelial growth, reaching 6.71 mm/day on wheat grains and 6.18 mm/day on peach palm leaves. Thus, when the inoculum based on peach palm leaves is utilized, the immersion water used for preparing this support can be used for preparing the PPLDA maintenance culture medium, diminishing the production costs of Pleurotus mushrooms. Data also showed that when Pleurotus sajor-caju was cultivated on peach palm leaves, using PPL as inoculum support, the fruiting bodies production parameters (Y = 47%, BE = 3% and Pr = 0.2 g/day) did not differ from that obtained using WG.(AU)

Assuntos

RESUMO

Este trabalho avaliou a utilização da água de imersão das folhas de pupunheira como componente do meio de cultivo para manutenção da cepa fúngica e a produção de inóculo de Pleurotus spp. utilizando como suporte folhas de pupunheira, um resíduo agrícola. Ainda, para verificar a capacidade do inóculo à base de folhas de pupunheira (FP) de produzir corpos frutíferos, foi realizado um experimento comparando FP com o inóculo à base de grãos de trigo (GT). Para tanto, realizou-se a comparação das velocidades de crescimento radial entre o meio de cultivo TDA (extrato de trigo, dextrose e ágar) utilizado para a manutenção de fungos do gênero Pleurotus e o meio FPDA (água de imersão de folhas de pupunheira, dextrose e ágar), e a comparação das velocidades de crescimento linear entre os grãos de trigo, utilizados como suporte para o inóculo de fungos do gênero Pleurotus e as folhas de pupunheira. O meio de cultivo TDA apresentou velocidade radial superior ao meio FPDA para as duas espécies, no entanto, o tipo de suporte não influenciou significativamente a velocidade de crescimento linear de P. ostreatus, que apresentou 6,71 mm/dia em grãos de trigo e 6,18 mm/dia em folhas de pupunheira. Assim, quando o inóculo à base de folhas de pupunheira é utilizado, a água de imersão deste suporte pode ser aproveitada para a confecção do meio de cultivo de manutenção (FPDA), diminuindo os custos produção. Observou-se que Pleurotus sajor-caju , quando cultivado em folhas de pupunheira utilizando inóculo FP, apresentou cerca de 47% de rendimento, 3% de eficiência biológica e 0,2 g/dia de produtividade, sem diferença significativa com o inóculo GT.

This study evaluated the use of immersion water from peach palm leaves (PPLDA) as a component of the culture medium for the maintenance of Pleurotus spp. and the use of agricultural waste, peach palm leaves, as inoculum support for the fungi. The performance of the inoculum based on peach palm leaves (PPL) for the production of Pleurotus spp. fruiting bodies was compared with that using wheat grains (WG) as inoculum support. PPLDA culture medium (immersion water of peach palm leaves, dextrose, and agar) showed a lower radial velocity of mycelial growth for both fungi than that obtained with the culture medium WDA (wheat extract, dextrose and agar), commonly used as maintenance medium for Pleurotus spp. However, the type of inoculum support does not significantly influence the linear velocity of P. ostreatus mycelial growth, reaching 6.71 mm/day on wheat grains and 6.18 mm/day on peach palm leaves. Thus, when the inoculum based on peach palm leaves is utilized, the immersion water used for preparing this support can be used for preparing the PPLDA maintenance culture medium, diminishing the production costs of Pleurotus mushrooms. Data also showed that when Pleurotus sajor-caju was cultivated on peach palm leaves, using PPL as inoculum support, the fruiting bodies production parameters (Y = 47%, BE = 3% and Pr = 0.2 g/day) did not differ from that obtained using WG.

Assuntos

RESUMO

Edible mushrooms are high nutritional value foods, which contain proteins, fibers, minerals, vitamins, and carbohydrates. Among their carbohydrates are some polysaccharides with recognized therapeutic effects. It was reported in this manuscript the structural characterization and antinociceptive and anti-inflammatory activities of an exopolysaccharide (EPS) produced by Pleurotus sajor-caju. The purified EPS was a mannogalactan (PEIsR), which was composed by mannose (37.0%), galactose (39.7%), and 3-O-methyl-galactose (23.3%). The polysaccharide was purified by freeze-thawing and dialysis, and it was characterized by GC-MS analysis and NMR spectroscopy. The mannogalactan is constituted by a main chain of (1 → 6)-linked α-D-Galp and 3-O-methyl-α-D-Galp units. Some of the α-D-Galp units were substituted at O-2 by non-reducing end units of ß-D-Manp. According to the literature review conducted, this is the first time that a methylated polysaccharide was observed on EPS of P. sajor-caju. The mannogalactan was able to reduce the nociception, in vivo, in the writhing and formalin tests and also reduced the carrageenan-induced paw edema, which indicates that it could be an effective antinociceptive and anti-inflammatory agent.

Assuntos