RESUMO

The production of mixed silages can be an essential strategy for storing and processing feed for ruminants in arid and semi-arid regions. This study aimed to evaluate the effect of inclusion levels of forage cactus in sorghum silage on chemical-bromatological composition, losses, in vitro digestibility, and fermentative profile. Sorghum silages were produced by adding 0, 10, 20, 30, and 40% forage cactus based on natural matter. Experimental silos were filled with the mixtures and hermetically sealed. The silos were opened after 34 days of fermentation, and the samples were analyzed for composition, digestibility, fermentative profile, and losses in silage. The inclusion of forage cactus presented a negative quadratic influence (P < 0.05) on the contents of dry matter (DM), ether extract, neutral detergent fiber, acid detergent fiber, and cellulose of sorghum silage. The DM concentration decreased from 35.83 to 25.43% for the control treatment (0%) to the 20% treatment, followed by stabilization at values close to 26 ± 1% in subsequent levels. Digestibility in vitro and the total digestible nutrients of the silages increased linearly (P < 0.05) with the inclusion of forage cactus. However, there was a linear increase (P < 0.05) of pH, ammonia nitrogen, acetic acid, and butyric acid with the inclusion of forage cactus, reaching values indicative of the limitation of the fermentation process from the level of 20% inclusion. Including forage cactus in sorghum silage did not affect (P > 0.05) losses by gases, effluents, and DM recovery from silage. Adding up to 10% of forage cactus can benefit chemical-bromatological characteristics, digestibility, and fermentation of sorghum silage.(AU)

A produção de silagens mistas pode ser importante estratégia para armazenamento e beneficiamento dos alimentos para ruminantes em regiões áridas e semiáridas. Objetivou-se avaliar efeito de níveis de inclusão de palma forrageira na ensilagem do sorgo sobre composição químico-bromatológica, perdas, digestibilidade in vitro e perfil fermentativo. Foram produzidas silagens de sorgo com adição de 0, 10, 20, 30 e 40% de palma forrageira com base na matéria natural. Utilizou-se silos experimentais preenchidos com as misturas e fechados hermeticamente. Após 34 dias de fermentação os silos foram abertos e as amostras analisada quanto a composição, digestibilidade, perfil fermentativo e perdas na ensilagem. A inclusão de palma forrageira influenciou de forma quadrática negativa (P < 0,05) os teores de matéria seca (MS), extrato etéreo, fibra em detergente neutro, fibra em detergente ácido e celulose da silagem de sorgo. The DM concentration decreased from 35.83 to 25.43% for the control treatment (0%) to the 20% treatment, followed by stabilization at values close to 26 ± 1% in subsequent levels. A digestibilidade in vitro e os nutrientes digestíveis totais das silagens aumentaram linearmente (P < 0,05) com a inclusão de palma forrageira. Contudo, houve incremento linear (P < 0,05) do pH, nitrogênio amoniacal, ácido acético e ácido butírico com a inclusão de palma forrageira, atingido valores indicativos de limitação do processo fermentativo a partir do nível de 20% de inclusão. A inclusão de palma forrageira na ensilagem do sorgo não influenciou (P > 0,05) as perdas por gases, efluentes, e recuperação de MS da silagem. A adição até 10% de palma forrageira pode ser recomendada para beneficiar características químico-bromatológica, digestibilidade e fermentação da silagem de sorgo.(AU)

Assuntos

RESUMO

Tropical legumes are used to prepare mixed silages to enrich the crude protein (CP) content. In This context, objective of this study was to evaluate the dynamics of fermentation and quality of maize silage with different levels of Pigeon pea. The experimental design was entirely randomized, with four repetitions. The treatments comprised maize silages with six levels of added Pigeon pea (0, 20, 40, 60, 80, and 100%), calculated based on natural matter. The maize hybrid and Pigeon pea varieties used were B 2800 PWU and Cajanus cajan cv. BRS Mandarin, respectively. For the silage, the maize and Pigeon pea were harvested when they reached 335.7 g kg-1 dry matter (DM) and 281.3 g kg-1 DM, respectively. The results revealed that the added of up to 40% Pigeon pea in maize silages promote nutritive increment without compromising their fermentative profile of the silage. Exclusive Pigeon pea silage (100%) undergoes fermentative losses that compromise the silage quality. Therefore, mixed silages of maize with Pigeon pea, with appropriate levels of addition, are a viable alternative to increase the nutritive value of silages, mainly the CP content, contributing to reducing the cost of acquisition of protein salts.(AU)

As leguminosas tropicais têm sido utilizadas para a confecção de silagens mistas para enriquecer os teores de proteína bruta (PB). Neste contexto, o objetivo deste estudo foi avaliar a dinâmica da fermentação e qualidade da silagem de milho com níveis de feijão guandu. O delineamento experimental utilizado foi o inteiramente casualizado, com quatro repetições. Os tratamentos foram constituídos da silagem de milho com seis níveis de feijão guandu (0; 20; 40; 60, 80 e 100%), calculado com base na matéria natural. O híbrido de milho e a variedade de feijão guandu utilizados foram o B 2800 PWU e o Cajanus cajan cv. BRS Mandarim, respectivamente. Para a ensilagem, o milho e o feijão guandu foram colhidos quando atingiram 335,7 g kg-1 de MS (matéria seca) e 281,3 g kg-1 MS, respectivamente. Os resultados mostraram que a adição de até 40% de feijão guandu na ensilagens de milho promove incremento nutritivo sem comprometer o seu perfil fermentativo da silagem. Silagem exclusiva de feijão guandu apresenta perdas fermentativas que compromete a qualidade da silagem. Portanto, silagens mistas de milho com feijão guandu, combinadas com níveis adequados de adição, torna-se alternativa viável para incrementar o valor nutritivo da silagem, principalmente os teores de PB, contribuindo com redução do custo com aquisição de sais proteínados.(AU)

Assuntos

RESUMO

A total of twentymixtures of weed, B-Lac and molasses were prepared in orderto evaluate an accelerated liquid fertilizer (ALF) based on these plants. A mixture of 85% weed: water (1:1), 10% molasses and 5% B-Lac showed the best characteristics and was reproduced at a pilot scale. ALF was applied to lettuce using the following treatments: one foliar application per week of 10 mL L-1 (FA1), two foliar applications per week of 10 mL L-1 (FA2), one drench application of 50 mL L-1 every week (DA1), a drench application of 50 mL L-1 every two weeks (DA2) and a control without application (CWA). The variables evaluated were total yield, commercial yield, fresh weight, height, head diameter, percentage of dry matter and the concentration of foliar nitrogen, phosphorus, and potassium.The mixtures in the laboratoryand pilot phase were evaluated in a completely randomized design. The field phase was assessed in a completely randomized block design with five treatments and four replications. No significant differences were found between the treatments, except in the percentage of dry matter and potassium content, where FA2 showed the best results (2.35% and 541 mg plant-1, respectively). The highest total yield (26.4 t ha-1) and commercial (24.11 t ha-1) were achieved with DA2; however, the nutritional content was lower than that in the other treatments. Using homolactic fermentation it was possible to recycle weeds and produce ALF, which has potential as a biofertilizer according to its chemical characterization and effects shown on lettuce cultivation.(AU)

Foram preparadas vinte misturas de ervas daninhas, B-Lac e melaço para avaliar um fertilizante líquido acelerado (ALF) baseado nessas plantas. Uma misturade 85% erva:água (1:1), 10% melaço e 5% B-Lac apresentou as melhores características e foi reproduzida em escala piloto. A ALF foi aplicada à alface utilizando os seguintes tratamentos: uma aplicação foliar por semana de 10 mL L-1(AF1), duas aplicações foliares por semana de 10 mL L-1(AF2), uma aplicação via drench de 50 mL L-1a cada semana (AD1), uma aplicação via drench de 50 mL L-1a cada duas semanas (AD2) e um controle sem aplicação (CSA). As variáveis avaliadas foram produtividade total, produtividade comercial, massa fresca, altura, diâmetro da cabeça, porcentagem de matéria seca e concentração foliar de nitrogênio, fósforo e potássio. As misturas na fase de laboratório e piloto foram avaliadas em delineamentos inteiramente casualizados. A fase decampo foi avaliada em blocos casualizados com cinco tratamentos e quatro repetições. Não foram encontradas diferenças significativas entre os tratamentos, exceto no percentual de matéria seca e no teor de potássio, onde o AF2 apresentou os melhores resultados (2,35% e 541 mg planta-1, respectivamente). As maiores produtividades total (26,4 t ha-1) e comercial (24,11 t ha-1) foram obtidas com AD2; no entanto, o teor nutricional foi inferior aos demais tratamentos. Utilizando a fermentação homolática foi possível reciclar as ervas daninhas e produzir FLA, que tem potencial como biofertilizante de acordo com sua caracterização química e efeitos demonstrados no cultivo de alface.(AU)

Assuntos

RESUMO

In this study, the possibility of increasing fermentation efficiency of Saccharomyces cerevisiae on sugarcane bagasse (a type of lignocellulosic waste) was analyzed. Sugarcane bagasse was subjected to hydrothermal and acidic pre-treatment. Next, the enzymatic hydrolysis of raw biomass and each pre treated biomass was performed using CellicCtec® enzymatic complex to obtain sugarcane hydrolysate, hydrothermal hydrolysate and acidic hydrolysate. Next, these were fermented by S. cerevisiae to check if the by-products of enzymatic hydrolysis, furfural and acetic acid had an inhibitory effect on fermentation efficiency. Next, each pre-treated biomass was subjected to detoxification involving activated charcoal. Each detoxified biomass was tested for fermentation efficiency. The lignocellulosic composition for sugarcane hydrolysate, hydrothermal hydrolysate and acidic hydrolysate, varied significantly, and were found to be, for cellulose 36.7%, 27.7% and 63.7% respectively; for hemicellulose 22.2%, 4.4% and 12% respectively; and for lignin 21.2%, 27.7% and 28.7% respectively. The presence of furfural and acetic acid had a strong influence on the fermentation efficiency of S. cerevisiae, and affected the consumption of sugars in each biomass by more than 90%. Further, we found that the detoxification process increased fermentation efficiency by 12.7% for the hydrothermal hydrolysate while for the acidic hydrolysate no significant difference was observed. This study showed that fermentation with greater efficiency is viable through the combined use of hydrothermal pre-treatment and detoxification. This combination of methods also causes less pollution as compared with the method involving acid pre-treatment due to the reduced number of effluents produced.(AU)

Nesse trabalho avaliou-se a possibilidade de se aumentar a eficiência de fermentação de um hidrolisado de bagaço de cana submetido aos pré-tratamentos hidrotérmico (195 ºC, usando 200 rpm por 10 min) e ácido (0,5% (v/v) de ácido sulfúrico a 121ºC por 15 min) (carga de sólidos de 10% m/v). A hidrólise enzimática do material pré-tratado foi realizada utilizado o complexo enzimático CellicCtec® (60 FPU/gbiomassa seca, tampão citrato a 50 mM e pH 4,8) a 50ºC usando 150 rpm por 72h. Antes do processo de detoxificação, realizou-se um teste com a espécie de Saccharomyces cerevisiae para verificar se os compostos furfural (1 e 4g.L-1) e ácido acético (1 e 5% v/v) exerciam significativa inibição na espécie testada. O processo de detoxificação avaliou a concentração de carvão ativado (1, 3 e 5% m/v) e o tempo do processo (30, 45 e 60 min) a 30 ºC, 150 rpm por 24 h. A composição lignocelulosica da biomassa in natura e pré-tratada (hidrotérmico e ácido) foi para celulose (36,7, 27,7 e 63,7%), hemicelulose (22,2, 4,4 e 12%) e lignina (21,2, 27,7 e 28,7%), respectivamente e com rendimento mássico em torno de 60%. A presença de furfural e ácido acético exibiu forte influência na espécie considerada, chegando a prejudicar em mais de 90% o consumo de açúcares no meio. O processo de destoxificação aumentou 13% a eficiência de fermentação para o hidrolisado obtido hidrotermicamente, enquanto que para o ácido não houve diferença significativa. Obtendo assim uma fermentação com maior eficiência, tecnicamente viável e menos poluente.(AU)

Assuntos

RESUMO

The objective was to evaluate the inclusion of chitosan (CHI) and technical cashew nut shell liquid (CNSLt) as natural feed additives in cattle diets on nutrient digestibility, ruminal fermentation, and in vitro gas production kinetics. We conducted a completely randomized design with 5×4 factorial arrangement, with 20, 35, 50, 65, and 100% Tifton 85 hay and four additives, monensin (200 mg/kg DM), CNSLt (500 mg/kg DM), CHI (500 mg/kg DM), and CNSLt+CHI (500 mg/kg DM/each). Dry matter (DM) and organic matter (OM) digestibility showed a linear reduction according to forage levels. The highest DM digestibility was observed with CHI on cattle diets. Inclusion of CHI increased DM digestibility. The highest in vitro organic matter and crude protein (CP) digestibilities were observed for CNSLt+CHI. The in vitro dry matter digestibility increased linearly with concentrate in the diet. There was interaction of forage:concentrate ratio and the additives for neutral detergent fiber, acid detergent fiber and hemicellulose digestibility. Chitosan, CNSLt, and CNSLt+CHI promoted the lowest acetate:propionate ratio compared with monensin. Total gas production showed interaction of the forage:concentrate ratio and additives. Lag time was lowest with CNSLt+CHI. Chitosan and CNSLt can be considered alternative fermentation modulators to ionophores by improving nutrient digestibility and increasing ruminal propionate concentrations.(AU)

Assuntos

RESUMO

Potato waste was processed and used as a sole substrate for simultaneously producing antifungals and biopigments using Streptomyces spp. Out of three different Streptomyces isolates, strain SO6 stood out due to its ability to produce antifungals against economically important fungal phytopathogens and intracellular biopigments using potato waste powders without additional nutrients. This strain also showed the potential to secrete a broad range of enzymes for fermentation of eight sugars that could be involved in potato waste bioconversion. The results of the fermentation assay indicated that Streptomyces sp. strain SO6 degrades potato wastes during submerged fermentation, diminishing total dry weight and increasing reducing sugars from 0.3 to 3.6 mg·mL-1 and total proteins from 70.6 to 187.7 µg·mL-1. The results showed that Streptomyces strain SO6 was able to convert the potato waste into 0.96 mg·g-1 of diffusible antifungals and 1.75 mg·g-1 of reddish-purple biopigments. On the contrary, an absence of pigment production was observed during the fermentation of the commercial medium used as reference. According to our results, replacement of commercial culture media with available low-cost agroindustrial wastes for producing bioactive chemicals is a real opportunity to enhance the Streptomyces pigment production and antibiotic sustainability with cost-competitiveness. To our knowledge, this is the first report on the simultaneous production of biopigments and diffusible antifungal antibiotics produced by Streptomyces spp. using potato solid waste as the sole nutrient source.

Assuntos

RESUMO

Various bio-based processes depend on controlled micro-aerobic conditions to achieve a satisfactory product yield. However, the limiting oxygen concentration varies according to the micro-organism employed, while for industrial applications, there is no cost-effective way of measuring it at low levels. This study proposes a machine learning procedure within a metabolic flux-based control strategy (SUPERSYS_MCU) to address this issue. The control strategy used simulations of a genome-scale metabolic model to generate a surrogate model in the form of an artificial neural network, to be used in a micro-aerobic fermentation strategy (MF-ANN). The meta-model provided setpoints to the controller, allowing adjustment of the inlet air flow to control the oxygen uptake rate. The strategy was evaluated in micro-aerobic batch cultures employing industrial Saccharomyces cerevisiae yeast, with defined medium and glucose as the carbon source, as a case study. The performance of the proposed control scheme was compared with a conventional fermentation and with three previously reported micro-aeration strategies, including respiratory quotient-based control and constant air flow rate. Due to maintenance of the oxidative balance at the anaerobiosis threshold, the MF-ANN provided volumetric ethanol productivity of 4.16 g·L-1 ·h-1 and a yield of 0.48 gethanol .gsubstrate-1 , which were higher than the values achieved for the other conditions studied (maximum of 3.4 g·L-1 ·h-1 and 0.35-0.40 gethanol ·gsubstrate-1 , respectively). Due to its modular character, the MF-ANN strategy could be adapted to other micro-aerated bioprocesses.

Assuntos

RESUMO

This study evaluated the bioproduction of 1,3-propanediol by Lactobacillus diolivorans in the medium based on agro-industrial residues and vegetal biomass substituting the MRS medium components. It was performed on a set of acid treatments and batch fermentations assays with crude glycerol (TCG) from biodiesel production, corn steep liquor (CSL), and cactus cladode hydrolyzate (CCH). Firstly, it was carried out on batch fermentation with different pure glycerol concentrations in MRS medium which was carried out, and the best condition achieved 4.66 g/L and 0.61 g/g of 1,3-PDO production and yield, respectively. Then, the TCG was evaluated, and a discrete increase of 1,3-PDO was observed. The replacement of the MRS medium nutrients by CLS was assessed, at different concentrations, for bacteria growth, and 5% of CLS reproduced the same biomass formation compared to the bacteria growth in MRS medium. It was also added cactus cladode hydrolyzate as the only sugar source, which showed a 1,3-PDO production close to the medium with pure glucose. Finally, a B-complex vitamin was added to the batch fermentation medium composed of TCG, CLS, and CCH, replacing all the costly MRS components. In this medium, the production of 1,3-propanediol was 6.57 g/L with a yield of 0.75 g/g. It means an increment of 29% and 19%, respectively, compared to MRS medium. Therefore, the combination of treated crude glycerol, corn steep liquor, and cactus cladode hydrolyzate has excellent potential for 1,3-PDO production by L. diolivorans.

Assuntos

RESUMO

Generally, the selection of fructans prebiotics and probiotics for the formulation of a symbiotic has been based on arbitrary considerations and in vitro tests that fail to take into account competitiveness and other interactions with autochthonous members of the intestinal microbiota. However, such analyzes may be a valuable step in the development of the symbiotic. The present study, therefore, aims to investigate the effect of lactobacilli strains and fructans (prebiotic compounds) on the growth of the intestinal competitor Klebsiella oxytoca, and to assess the correlation with short-chain fatty acids production. The short-chain fatty acids formed in the fermentation of the probiotic/prebiotic combination were investigated using NMR spectroscopy, and the inhibitory activities were assessed by agar diffusion and co-culture methods. The results showed that Lactobacillus strains can inhibit K. oxytoca, and that this antagonism is influenced by the fructans source and probably associated with organic acid production.

Assuntos

RESUMO

This study aimed to model the aflatoxin B1 (AFB1) production by A. flavus in wheat grains during malting for craft beer. A total of sixty-four different combinations of grains steeping degree (ST; 41, 43, 45 and 47%), temperature (13, 15, 17 and 19 °C) and time of germination (48, 72, 96 and 120 h), comprising the range of malting conditions that allow the production of quality malt, were assayed. AFB1 was produced in a range of 15.78 ± 3.54 µg/kg (41% ST, 13 °C for 48 h) to 284.66 ± 44.34 µg/kg (47% ST, 19 °C for 120 h). The regression model showing an acceptable fit to the experimental data (adjusted R2 0.84) for AFB1 as a function of grains steeping degree, temperature and time of germination. Results showed that AFB1 levels in wheat malt increase with increase of the temperature or time of germination. Within the range of tested malting conditions, no significant effects were observed for steeping degree on AFB1 levels in wheat malt. The generated model is useful to estimate the AFB1 levels in wheat malt. Findings highlight overall that if wheat grains are contaminated with A. flavus, AFB1 might be produced in malt in levels above the limits set by regulatory agencies, regardless the steeping conditions used.

Assuntos